- What is the strongest concrete mix ratio?
- What happens if you don’t add enough water to concrete?
- Is quikrete as strong as regular concrete?
- How many bags of Postcrete do you need per post?
- What happens if you put too much cement in concrete?
- Is 2 feet deep enough for fence posts?
- How long does 4 inches of concrete take to cure?
- Can I pour concrete in a hole full of water?
- How many bags of concrete do I need for a 4×4 post?
- Can you put a thin layer of concrete over concrete?
- What happens if you add too much water to quikrete?
- Is the concrete in Hoover Dam still curing?
- Is it OK if it rains after pouring concrete?
- Does concrete need air cure?
- How long does it take for concrete to cure in a post hole?
- Can you cover concrete before it sets?
- Can I mix quikrete in the hole?
- What happens if you don’t add sand to cement?
- Will wooden posts rot in concrete?
- How long will concrete last?
- Will concrete set under soil?
What is the strongest concrete mix ratio?
Mixing 1 part cement to 6 parts ballast creates concrete suitable for driveways, paths and patios, and increasing the ratio to 1:8 gives foundation-strength concrete.
It is of course possible to add other materials to increase the strength of the concrete – these often include steel reinforcing bars (“rebar”)..
What happens if you don’t add enough water to concrete?
If there is too much water, the resulting concrete will be weak and will have poor surface qualities. If there is not enough water, the concrete will be hard to work into place. Concrete that is too dry on the left, and too wet on the right.
Is quikrete as strong as regular concrete?
Quikrete Fast-Setting Concrete Mix is easy to use — just add water — and it sets in 20 to 40 minutes. It’s the most efficient option for setting posts for things like mailboxes, fences and lamps. … That’s stronger than the concrete used for foundations on most homes.
How many bags of Postcrete do you need per post?
You’ll need to bury the posts at least 2ft In the ground. As for how many bags of postcrete you need per post, that’s purely dependant on how big you make the post holes. As a rule of thumb, when using standard post hole diggers, I average 1 bag per post. For larger holes I would allow 1.5 bags to 2 bags per hole.
What happens if you put too much cement in concrete?
Cement Amount: As a thumb rule, increasing the cement increases the strength. … Since major force transfer in a concrete/mortar matrix is from sand-sand interaction, excess cement will turn the mortar very brittle since cement particles cannot transfer normal contact force – they are good at providing shear strength.
Is 2 feet deep enough for fence posts?
The minimum depth that you should dig your fence post holes for panel sections is 2 feet. A general formula is to dig the holes one-third to one-half of the post’s aboveground height. The deeper you dig the holes, the more stability your fence has, but you must also purchase longer posts.
How long does 4 inches of concrete take to cure?
When waiting for concrete to dry, keep these timeframes in mind: 24 to 48 hours – after inital set, forms can be removed and people can walk on the surface. 7 days – after partial curing, traffic from vehicles and equipment is okay. 28 days – at this point, the concrete should be fully cured.
Can I pour concrete in a hole full of water?
The good news is that you can pour the concrete in water. … The biggest issue with pouring concrete under water is movement. If the water is moving, it can wash away the cement paste that’s holding the sand and gravel together. But if the water is calm, then it’s not a problem at all.
How many bags of concrete do I need for a 4×4 post?
Mix two 50lb bags of concrete with water in a mixing tub or 5-gallon bucket. Add concrete into the hole and around the 4” x 4”. Depending on your climate, let concrete set up for 24 – 48 hours.
Can you put a thin layer of concrete over concrete?
Yes, you may pour a concrete pad overlay over an existing slab. You need to consider the added height and weight of the overlay on the existing structure. Overlays may include polymers, portland cement concrete, or epoxies.
What happens if you add too much water to quikrete?
NOTE: the more water that is added to the mix the weaker it becomes; adding one extra quart of water per 80 lb bag can reduce the strength of the concrete by up to 40%.
Is the concrete in Hoover Dam still curing?
Concrete in the core portion of the gigantic Hoover dam in Nevada, USA is still continuing to cure according to engineers. That is in spite of the fact that the dam was built way back in 1935 and a huge network of 1 inch dia.
Is it OK if it rains after pouring concrete?
If the concrete is still fresh (around 2-4 hours after pouring), it’s important to cover the surface to protect it. However, once the concrete has been finished (between 4-8 hours after pouring), and has set hard enough for walking on, the effects of rain should be minimal.
Does concrete need air cure?
The most crucial time for strength gain of concrete is immediately following placement. In field conditions, heat and wind can dry out the moisture from the placed mixture. … Concrete that is allowed to dry in air will gain only 50% of the strength of continuously moist-cured concrete.
How long does it take for concrete to cure in a post hole?
The concrete sets up in 20 to 40 minutes, so you can quickly move on to the next stage of the project (a great convenience when setting fence posts) or backfill the hole to finish the job. Under normal curing conditions, you can apply heavy weight to the post (a basketball backboard, for example) after just 4 hours.
Can you cover concrete before it sets?
When the temperatures drop, new concrete should be covered with concrete insulating blankets (or, in a pinch, old household blankets!). Protect new concrete from the cold for the first two to three days—up to a week, if it’s very cold—after which it should be strong enough to handle it without risk of damage.
Can I mix quikrete in the hole?
Whether you are building a new fence, setting a mailbox or anchoring a basketball goal or play set, QUIKRETE® Fast-Setting Concrete is the ideal product for the job. With Fast-Setting Concrete there is no mixing or tools required – You simply pour the dry mix right from the bag into the hole, then add water.
What happens if you don’t add sand to cement?
If you mean to mix portland cement with gravel only, with no sand, it will be much more prone to cracking and will eventually disintegrate, since the sand reinforces the bond between the cement and the gravel.
Will wooden posts rot in concrete?
Simply setting the posts in concrete does create a condition that will accelerate rot in the bottom of the posts. With pressure-treated posts, the rot will be slow. … The concrete at the top should be sloped away from the post to grade level to avoid water pooling around the base.
How long will concrete last?
100 yearsFor larger projects such as buildings and homes, the concrete should last 30 to 100 years or more depending on the construction style as well as method of installation. Many times, a concrete shell of a building or home can be reused when the other materials such as wood begin to deteriorate.
Will concrete set under soil?
As noted before, concrete doesn’t dry out to harden, it cures through a chemical reaction that needs water to facilitate the reaction. If the ground is dry, the ground will absorb moisture from the concrete and it won’t cure properly. The ground should be very moist and compacted as well as you can manage.